Will a bike run with a bad stator?

Can you ride a bike with a bad stator?

If the stator is bad, the bike won’t run at all. The stator generates energy for spark. Assuming the air cleaner is clean and other general maintenance has been performed, if the bike won’t kick start but runs as you state, the problem is probably either the spark plug and/or fuel delivery.

How do I know if my stator is bad?

Insert each probe into a stator socket. You should read around 0.2 to 0.5 ohms. If you show an open circuit with the “Open” or infinity reading or have higher resistance, then the stator is bad and you must replace it. If these tests all produce positive results, then the stator itself is good.

How do I know if my stator or rectifier is bad?

Key Signs to Look For

You won’t have any trouble diagnosing the faulty regulator rectifier if the battery is the cause. You’ll note signs right away like poor starts, fluctuating meter readings, and dimmed headlights. around 13 volts, the bike will start to drain the battery.

Can a bad stator drain a battery?

Will a bad stator drain a battery? As far as the battery, yes a bad stator/regulator can destroy a new battery. If it’s run at a very low voltage without being recharged then it can be destroyed. … In most cases if we replace a stator or regulator the battery has to be changed as well as it won’t hold a charge.

THIS IS IMPORTANT:  Which is the costliest bike in the world?

Will a bad rectifier damage a stator?

If the rectifier/regulator failure results in too low resistance the stator probably will burn (too much current). If I disconnect the rectifier/regulator the voltage will go up, but how high? Is it possible that the voltage will go high enough to destroy the isolation?

Can you bypass a stator?

Can you bypass a stator? The cost of a new stator can be hundreds of dollars. Without a good stator, your engine will run poorly or not at all. This solution completely bypasses the stator by using a 12 volt battery to power the ignition system.

Will a bad rectifier cause no spark?

The regulator/ rectifier is a voltage regulator that keeps the battery supplied with a steady 13.4 dc volts no matter what the stator is putting out, which is AC volts that varies with engine RPM. A bad regulator/ rectifier will result in a dead battery, and once the battery is competely dead you will not get a spark.

What causes a stator to go bad?

To answer why stators fail, it is because the coating on the windings breaks down, usually because of heat, causing a short which can also burn the fine wire of the winding in two at the short causing an open circuit. The way to prevent failures is to prevent the heat.

What happens when a regulator rectifier goes bad?

Depending on the location of the regulator rectifier, the part can easily overheat. … Ground connections are important for good voltage, and if there is faulty voltage, the regulator rectifier can run hot. Bad grounding, corroded battery connection and poor or loose battery connections will cause faulty voltage.

THIS IS IMPORTANT:  Can I clean my bike with WD40?